Volume 2, Issue 2, December 2018, Page: 58-65
Slug Frequency in Horizontal Pipeline Subject to a Sudden Contraction: State of the Art and Laboratory Testing Data
Ibtissem Belgacem, Hydraulic Department, National Polytechnic School, Algiers, Algeria
Reda Mekhlouf, Shimadzu Software Development, Montréal, Canada
Received: Oct. 16, 2018;       Accepted: Nov. 7, 2018;       Published: Dec. 25, 2018
DOI: 10.11648/j.ep.20180202.15      View  906      Downloads  118
Abstract
Liquid-gas two-phase flows are widely encountered in industrial applications including chemical processes, petroleum engineering and energy manufacturing units systems. Of all flow patterns encountered in field operations, slug flow is the dominant one in horizontal and near horizontal pipelines, and is also the most complicated one. Of all flow topological configurations, slug flow is the most concerning from the operational perspectives. It is characterized by an alternate flow of liquid slugs and gas pockets, resulting in an inherently unsteady hydrodynamic behavior. Frequency of the slug has important significance on gas-liquid two-phase flow. This paper presents the results of experimental study of gas-liquid slug flow in a horizontal pipe subjected or not to a sudden contraction. The first objective of this study is to present a state -of -the art of correlations concerning slug frequency; an analysis on the accuracy of these correlations is performed based on direct comparison against experimental data. It has been found that none of the slug frequency correlation was able to produce accurate prediction. In this study, the effects of sudden contraction on slug frequency regime were also investigated experimentally through the analysis of slug persistence and frequency, it has been found that: i) the slug flow prevails before and after the contraction, ii) frequencies of the structures persist across the contraction.
Keywords
Two-Phase Flow, Slug, Frequency, Closure Equations, Contraction
To cite this article
Ibtissem Belgacem, Reda Mekhlouf, Slug Frequency in Horizontal Pipeline Subject to a Sudden Contraction: State of the Art and Laboratory Testing Data, Engineering Physics. Vol. 2, No. 2, 2018, pp. 58-65. doi: 10.11648/j.ep.20180202.15
Copyright
Copyright © 2018 Authors retain the copyright of this article.
This article is an open access article distributed under the Creative Commons Attribution License (http://creativecommons.org/licenses/by/4.0/) which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.
Reference
[1]
Mandhane, J. M., Gregory, G. A., & Aziz, K. (1974). A flow pattern map for gas—liquid flow in horizontal pipes. International Journal of Multiphase Flow, 1(4), 537-553.
[2]
Taitel, Y., & Dukler, A. E. (1976). A model for predicting flow regime transitions in horizontal and near horizontal gas‐liquid flow. AIChE Journal, 22(1), 47-55.
[3]
Belgacem, I., Salhi, Y., SI-Ahmed, E. K., Legrand, J. (2105). Development and statistical characterization of slug in two-phase flow along horizontal pipeline “. Mechanics & Industry.
[4]
Gregory, G. A., Scott, D. A., 1969. Correlation of liquid slug velocity and frequency in horizontal cocurrent gas–liquid slug flow. AIChE J. 42, pp. 901–907.
[5]
Greskovich, E. J., & Shrier, A. L. (1972). Slug frequency in horizontal gas-liquid slug flow. Industrial & Engineering Chemistry Process Design and Development, 11(2), 317-318.
[6]
Taitel, Y. and A. E. Dukler, 1977. A Model For Slug Frequency During Gas-liquid Flow in Horizontal and Near-Horizontal Gas-Liquid Flow, Int. J. of Multiphase Flow, Vol. 19, No. 5, pp. 829-838.
[7]
Heywood, N. I., & Richardson, J. F. (1979). Slug flow of air—water mixtures in a horizontal pipe: Determination of liquid holdup by γ-ray absorption. Chemical Engineering Science, 34(1), 17-30.
[8]
Tronconi, E., 1990. Prediction of slug frequency in horizontal two-phase slug flow. AIChE J. vol. 36, pp. 701–709.
[9]
Nydal, O. J., Pintus, S., Andreussi, P., 1992. Statistical characterization of slug flow in horizontal pipes. Int. J. Multiphase Flow 18, pp. 439–453.
[10]
Hill, T. J., & Wood, D. G. (1990). A new approach to the prediction of slug frequency. In 65 th Annual Technical Conference and Exhibition of SPE, September (pp. 23-26).
[11]
Hill, T. J., & Wood, D. G. (1994). Slug flow: Occurrence, consequences, and prediction (No. CONF-940879--). Society of Petroleum Engineers, Richardson, TX (United States).
[12]
Manolis, I., Mendes-Tatsis, M., Hewitt, G., 1995. The effect of pressure on slug frequency on two-phase horizontal flow. Presented at the 2nd International Conference on Multiphase Flow, Kyoto, Japan (cité par El safran 2009).
[13]
Woods, B. D., Hanratty, T. J., 1999. Influence of Froude number on physical processes determining frequency of slugging in horizontal gas–liquid flows. Int. J. Multiphase Flow vol. 25, pp. 1195–1223.
[14]
Zabaras, G., 2000. Prediction of slug frequency for gas/liquid flows. SPE 65093. SPE J. 5 (3).
[15]
Shea, R., Eidsmoen, H., Nordsveen, M., Rasmussen, J., Xu, Z., Nossen, J., 2004. Slug frequency prediction method comparison. BHRG Multiphase Production Technology Proceedings, Banff, Canada.
[16]
Kadri, U., Mudde, R. F., Oliemans, R. V. A.(2008). A growth model for dynamic slugs in gas/liquid horizontal pipes. In Proc. BHR Conf., Banff, Canada, pp. 241–254.
[17]
Al-Safran, E. (2009). Investigation and prediction of slug frequency in gas/liquid horizontal pipe flow. Journal of Petroleum Science and Engineering, 69(1), 143-155.
[18]
Hernandez Perez, V., Azzopardi, B. J., & Morvan, H. (2007). Slug flow in inclined pipes. In Proceedings of 6th international conference on multiphase flow (pp. 9-13).
[19]
Azzopardi, B. J., Ijioma, A., Yang, S., Abdulkareem, L. A., Azzi, A., & Abdulkadir, M. (2014). Persistence of frequency in gas–liquid flows across a change in pipe diameter or orientation. International Journal of Multiphase Flow, 67, 22-31.
[20]
Al-Lababidi, S., Addali, A., & Mba, D. (2012). Upstream Multiphase Flow Assurance Monitoring Using Acoustic Emission. INTECH Open Access Publisher.
[21]
Belgacem, I., Salhi, Y., SI-Ahmed, E. K., Legrand, J., &Rosant, J. M. (2013). Experimental investigation of slug pattern in a horizontal two-phase flow. Computational Methods in Multiphase Flow VII. Wit transaction on Engineering Sciences, 79, 423-433.
[22]
Rodrigues, H. T., Morales, R. E., Mazza, R. A., & Rosa, E. S. (2007). A comparative study of closure equations for gas-liquid slug flow. In international congress of mechanical engineering- COBEM (Vol.19).
Browse journals by subject